Diagnosing the fuel pump is fairly easy as soon as you execute not listen it turn on, however its replacement requires a bit much more work. This write-up explains how to safely drain your gas tank, reduced it, and replace the dreaded fuel pump.

You are watching: 1999 honda accord fuel pump location


This article applies to the Honda Accord (1990-2002).

Your auto needs three points to start – fuel, spark, and also air – and when one or more of these fails to do an appearance, the engine will certainly not start. A fuel pump is supposed to wear the end over time; this is especially usual on vehicles with greater mileage. The usual instance in instead of a fuel pump top top a Honda chassis involves opening the access hatch discovered behind the seat and also simply replacing the pump. Unfortunately, fourth and fifth-generation Honda Accord owners seemed to have acquired the raw end of the deal once it concerns fuel pump accessibility. Fourth and fifth-generation Honda Accord owners lug the burden of having to drainpipe the gas, autumn the tank, and also disconnect every the fuel present to accessibility the pump. Here"s exactly how you have the right to replace the fuel pump and also save a couple of hundred dollars in labor.

*


Materials NeededSocket set3/8" ratchetFuel containerPliersRagsJackJack stands

Step 1 – Siphon the end the gas tank

Take a tube and also insert it right into the tank, with the gas cap. Produce a vacuum through blowing into the tank through the tube and pour the gasoline right into a safe container. Drainpipe out as lot gas together possible.

Figure 1. Siphon gas the end of the tank.
Pro Tip

Use a vacuum pump, if one is available, to prevent accidentally sipping increase gasoline.


Featured Video: how to Siphon Gas there is no a Pump


Step 2 – Raise and secure the car

Use a jack on among the car"s safety points and raise it. Place jack stands under the car to secure it into the air.

(Related Article: how to Jack Up your Accord - tennis2007.org)

*
Figure 2. Raise and also support the car.

Step 3 – Disconnect the fuel-sending unit

The fuel-sending unit is uncovered underneath the accessibility hatch located inside the trunk. Open the hatch and also disconnect it.

Figure 3. Disconnect the fuel-sending unit.

Step 4 – start disconnecting the fuel lines

There are four fuel currently that should be disconnected, all of which are located behind the left behind wheel. First, eliminate the rear left wheel. Once off, begin disconnecting the fuel lines. There are two hard-lines, a high-pressure line, one brass line the connects straight to the tank, and a big line because that fuel input.

Figure 4. The first two fuel lines that have to be disconnected.Figure 5. The high-pressure fuel line.Figure 6. The brass fuel hard-line.Figure 7. The gas-receiving line.

Step 5 – eliminate the tank straps

The tank straps are hosted in location using 14mm bolts. Location a hydraulic jack v a lengthy piece of lumber under the tank. Ease the straps and also remove them. As soon as the straps room off, progressively lower to relieve the press from the jack and also lower the tank.

Figure 8. The gas tank straps.
Pro Tip

The exhaust heat shield may need to be eliminated to access one that the 14mm strap bolts.


Step 6 – remove the fuel pump

First, disconnect the clip on optimal of the fuel pump. Then, usage a 10mm socket to remove the nuts that secure the fuel pump come the tank. When all the nuts space off, traction the unit out from the tank and remove the pump native its bracket.

Figure 9. Disconnect the clip ~ above the fuel pump.Figure 10. Eliminate the pump.

Step 7 – download the new pump

Mount the brand-new pump come its holder and be sure to correctly place it within the gas tank. There is a tiny plastic container situated inside the tank. Position the pump so the it sits within the plastic container, where the fuel pick-up is.

Figure 11. Mount the brand-new fuel pump.

See more: Watch H2O: Just Add Water Season 4 Episode 1 Part 1, H2O: Just Add Water

Step 8 – mountain the fuel tank and also lines

Once done, advanced the tank and also secure the straps. Reconnect every the fuel lines and also be certain to tighten the high-pressure line. Placed the wheel ago on and also lower the vehicle. Open up the gas cap, pour some fuel and also start her up!

Figure 12. Raise the tank and reconnect every the fuel lines.

Featured Video: Honda Accord Fuel Pump and also Fuel Tank Removal


Related Discussion